I dont have the old gas tank. My wife was fueling up the car and was doused with gas about 5 seconds after the automatic shut off engaged on the fuel pump. The case manager would not return her call. The fuel pump shuts off but then fuel comes gushing back up out of the tank. The dealer will not offer any assistance. Within the last 3 months, the gas tank overflows whenever we fill up with gas. The fuel pump shut off when the Durango was full but immediately after the gas came spraying out of the tank but the pump was off.
However, the part needed for the repair was unavailable. Recall info is 09v003000 please respond and kindly investigate this situation and advise me of my next step with local dealer. The vehicle was taken to the dealer who inspected the failure and informed her she needed to replace the fuel tank, the fuel pump modular and she needed a system update. This obvious fueling defect is cause for general public concern for many reasons; excessive skin contact with chemicals, threat of major fire or explosion that could injure, harm or kill individuals and is an environmental hazard to the community. This is documented in countless forums and videos online. Will do it most times unles shutting the fuel pump off before the tank is fuel.
This happens more in warmer weather but can happen any time. It is located on the passenger side floorboard to the right- kinda of hard to find- but it is there- bolted on with 1 10 mm blot. You can easily accomplish this by using a spark tester to check for spark. When the consumer arrived at the dealer, they informed the consumer, the recall had not been performed and the computer read as incomplete. The contact stated after approaching a traffic light, the vehicle stalled. For the past 3 months during every fill-up, at various gas stations, fuel pump nozzle will click off when tank is full and then a few seconds later gasoline will forcibly flow from the tank spilling about a quart of fuel on the side of vehicle and on the cement.
The vehicle was towed to a private mechanic where it was diagnosed that the fuel pump module needed to be replaced. The manufacturer was not aware of the failure. The 2005 Durangos are under a recall for the exact same problem, so they obviously completely ignored the problem. The contact stated that the inside of the vehicle had a gasoline odor after the fuel pump assembly was replaced. If you like this solution please rate it. The approximate failure mileage was 21,000.
It runs all over down the side of the truck and splashes back usually landing on our feet and hands. It sprayed gas all over side of the vehicle and all over me and my clothes it was awful. We started chatting and he showed me a youtube video of another Durango doing the same thing and said hope you have an extended warranty. This is a condition that was not caused by the owner or from normal operation of the vehicle. The vehicle was not repaired. This causes fuel to spill onto the ground and down the side of my vehicle, and at times onto myself or my wife, which can be a safety hazard. Still, it's an effective test.
The failure recurred whenever the vehicle was refueled. But when the fuel pump fails slowly, your Dodge will start and run but with engine performance problems. The vehicle was towed to the dealer, who diagnosed that the fuel pump relay was defective and needed to be replaced. The vehicle was taken to the dealer again where it was diagnosed that the alternator needed to be replaced. The contact discovered pools of gasoline on top of the fuel pump assembly. You could always check the wire harness to the down stream O2 for corrosion. This is dangerous, easily repeatable, and terrible for the environment.
Whether the fuel pump has failed completely or is still barely hanging on. The consumer took the vehicle to her local mechanic, he suggested she take it to the dealer, because he noticed in the computer the fuel pump relay from a recall, had not been installed and that could have been the reason why the vehicle did not start. Your next step is to check to see what the fuel pressure is with a fuel pressure test gauge. The approximate failure mileage was 70,000. The vehicle was not taken to the dealer for diagnostic testing. However, further investigation on my part reveals that some not all were included, but yet some not included suffer the same symptom 2005 Dodge Durango were recalled for a faulty gas tank chek-valve that resulted in the exact same parts being replaced: the tank and inlet assembly. Fuel began spraying out of the vehicle onto the contact and the ground.
Thank You for using fixya. While adding fuel to the vehicle, the fuel pump indicator informed the contact that the fuel tank was full. You can find this tutorial in Spanish here: at: autotecnico-online. The current mileage was 71,000. This occurs nearly every time the fuel tank is filled up where we rely on the auto shut off to signal when the tank is full. The only thing we have done to correct the failure is to partially fill the gas tank.
The failure mileage was 70,000. Good luck and hope this helps. There was a similar problem with the 2005 Durango that justified a recall, and the same problem exists with the 2006, although there has been no recall. The consumer informed the mechanic, it was replaced in February 15, 2015, which was one of the three recalls performed. The contact was refueling the vehicle and when the fuel pump clicked to indicate the tank was full fuel began to spill out of the fuel tank. This should be fixed by Dodge. Consumer writes in regards to fuel pump relay recall not completed as stated by dealership work order.