It is part of a removable assembly of parts comprised of the fuel level sending unit, a filter screen and the pump. Answer Both you guys are right - you can change it either by removing the gas tank or by t … aking off the back seat, but it'll take the same amount of time either way. To replace the pump, remove the fuel pump socket, fuel pump and pulse damper from the sending unit bracket. After the leakage has stopped loosen both lines completely, then remove the bracket. It is a small black box with an electrical connector and a tube running into it. Confirm the cover of the part you are replacing has a black electrical pressure sensor on cover. Once both sides are loose catch any gasoline that may leak into a safe container.
Ensure you are using the correct size compressor, and clamp it on the line. Look for two small black boxes mounted on the firewall on the passenger side. In-tank pumps use fuel for cooling and lubrication. It is located under the vehicle approximately 2 feet inside from the fuel filler, right next to the inline fuel filter. These results can be reversed with a top-quality fuel pump replacement for Chevy Astro from AutoZone.
Clip On, Remove the bracket holding the filter to the frame and move it away from the frame for more clearance. Front brakes and pads were replaced, rotors were resurfaced. Purchase a crimping and flaring tool and two female threaded flare connectors and one male union. After the leakage has stopped loosen both lines completely, then remove the bracket. Special tools are required in some cases to remove the filter available at the parts store. It naturally consumes a high amount of fuel to do its duties.
On my 1995 they are both identical. After that, its simple but - unless you are certain that the problem is the fuel pump, try replacing the fuel filter first. One of the best kept secrets that cause a lot of trouble. Some models On the passengers side front of the motor, near the bottom you must raise the van and access it from below. I would not remove the bed. I do hope someone will contact me on this issue! Description: The fuel filter looks like a small coffee can, it is approximately 4 inches long and 2 inches in diameter and silver in color. The dealer has been very fair and repaired at low or now cost.
On your truck, it may be possible to access the pump without removing the tank. Fortunately excessive heat or sparks did not occur due to this failure. I bought the strainer don't remember how much, so it couldn't have been much and replaced it along with the pump. Remove the bolts at the ends so the straps come off and the tank can be lowered. Two bolts on the drivers side of the tank will drop the straps. Cut the fuel line at the crimp keeping the most good line as possible, slide the female connector on threads toward cut and flare the tubing. Another good test when … trouble shooting a fuel pump is to find the wire going to the pump and check to see if power is getting to it when you turn on the ignition.
. Some pumps are mounted to the tank with a locking ring that rotates with large pliers. Some are mounted to a hole in the tank with a matching round plate that has five or six screws. Another good test when trouble shooting a fuel pump is to find the wire going to the pump… its located by the frame underneath the van, mid-way on the drivers side. I squeeze the fittings gently on all six sides three positions with vice grips… The fuel filter is a silver or grey cylinder located underneath the driver's side against the inner frame halfway between the gas tank and the driver's door. Shifter was hard to move, dealer replaced shift cable. All of this was done before my car had 57,000 miles.
It will be a tremendous help. If these items are not with the kit, it's a good idea to replace them anyway. Big and powerful, your Chevy Astro surpasses other minivans in its utility and hauling ability. Not a terribly difficult job, but a pain in the rear none the less. Then check the area under the tank straps. Location: The filter is located in the fuel line almost directly under the drivers seat, attached to the inside of the frame rail. Locate the filter and determine if it is a bolt on or if it has special clips.
My van is a 1997 Astro and it has some serious transmission problems after going 30-40 miles and stoping at a light it jerks real hard and feels like I was hit in the back I have took it 3 times to get fixed and it still does it the service ingine light comes on when it starts doing it no one seems to know wheat wrong they just keep takeing my money and telling me its fixed when its no if some one could tell me what the problem is I would be very happy the fuel pump went out 900. Astro fuel pumps use pressure to feed gas from the fuel tank to the engine fuel injectors. Before installing the new pump in the tank, attach the in-tank electrical wires. More if you start breaking off bolts. So, you could be saving yourself a ton of frustration by replacing the filter first. Gas tanks are held in place with straps.
But, the truck can run pretty well with a pressure reading over 43psi. Fuel strainer is inside the module assembly. When that amount skyrockets, it means your Chevrolet Astro fuel pump isn't transporting fuel properly, and you need a replacement from AutoZone to lower your gas bill. Look for two small black boxes mounted on the firewall on the passenger side. They asked where is the fuel pump relay, not the fuel pump itself. Then remove the fasteners behind the fuel-filler door that hold the fuel-filler neck to the body. Install the pressure line and return hoses to the outside of the pump unit, then install the outside wires and reattach the tank with the straps and refasten the fuel-filler neck to the body.