Exceeding these weight ratings can affect stability and handling, which could result in death or serious injury. Fuel Filler Cap: Sportster Models See Fuel Filler Cap: Sportster Models. Tire cords or fabric become visible through cracked sidewalls, snags or deep cuts. Riding with excessively worn, unbalanced or underinflated tires can adversely affect stability and handling, which could result in death or serious injury. Do not leave the fob attached to the handlebars or store the fob in a saddlebag or Tour.
This 2007 Harley Sportster repair manual was prepared to suite the needs of individuals who poses basic knowledge in electrical and mechanical concepts. Using a worn tire can adversely affect stability and handling, which could result in death or serious injury. Free harley davidson motorcycle service manuals for download lots of people charge for motorcycle service and workshop manuals online which is a bit cheeky i reckon as they are freely available all over the internet 5 each online or download your harley davidson manual here for free. Install front wheel 1 , stock axle and stock axle nut. Operation is subject to the following two conditions: 1 This device may not cause harmful interference, and 2 This device must accept any interference received, including interference that may cause undesired operation. Aftermarket fasteners may not have the specific property requirements to perform properly.
If positive + cable should contact ground with negative cable connected, the resulting sparks can cause a battery explosion, which could result in death or serious injury. For those without basic knowledge, you should avoid performing complicated repairs to the 2007 Harley Sportster equipment as it may render it unsafe. Remove and discard the forwardmost fender support bolt 1. Follow tire data for correct cold tire inflation pressures. All other models: Install wheel spacers previously removed. Install snap plug in headlamp bracket.
Reinstall oil filler cap in tank. Do not load bulky items too far behind the rider or add weight to the handlebars or front forks. Place a shop cloth or other clean, dry cloth over rear brake master cylinder reservoir and left passenger foot peg if equipped. Screw the throttle adjustment screw in to increase friction on grip. A damaged or improperly installed check valve. Press and release button again to display time.
HandsFree Fobs are electronically assigned to the HarleyDavidson Smart Security System by a HarleyDavidson dealer so that the module can recognize a fob's unique signal. To reconnect, simply snapon spark plug cables to tops of spark plugs. High speed increases the influence of any other condition affecting stability and increases the possibility of loss of control. If the fob is present, the system disarms. Install valve stem assembly L, M or N on wheel.
. The gear shift lever is located on the left side of the motorcycle and is operated with the left foot. Avoid lugging the engine by not running the engine at very low speeds in higher gears. Loosen worm clamp and remove drain hose from frame clip. Failure to wear protective clothing could result in burns or other serious injury. Each handlebar control group contains a turn signal switch. If this happens, reduce speed and guide the motorcycle with a relaxed grip to a controlled condition.
Two-pin voltage regulator connector 2007 only Voltage regulator 2. Brake lamp and horn can be activated. Primary Chain Adjustment: Sportster Models. This action removes air from the drain hose and reduces the possibility of oil pump cavitation. If you ride under adverse conditions steep hills, heavy traffic, etc. Never try to pass another vehicle going in the same direction at street intersections, on curves, or when going up or down a hill.
Do not leave the curb or parking area without signaling. Tighten screws in a crosswise pattern to 84 108 inlbs 9. Function switch back of gauge 3. This maturing is natural and will enhance the custom quality of your HarleyDavidson motorcycle. Cleaners containing chlorine and silicone can impair brake function, which could result in death or serious injury. Do not adjust the primary chain tighter than specified.