When the throttle lever is pushed forward the throttle arm moves off the micro switch and allows the engine rpm to increase with lever movement. Remove the foam air filter. Become familiar with their meanings before reading the manual. Change oil immediately if the oil level begins to rise. Use a non-synthetic brush to clean the arrestor screen. Got a 04 Sportsman 500 that wasnt running- owner said it needed a stater and a new battery. Always use genuine Polaris parts.
Always drive within the sight of an adult. Clean and reinstall the drain plug. Telephone 763-542-0500 We, Polaris Industries Inc. Children must never add their own gasoline. A collision or rollover can occur quickly, even during routine maneuvers like turning, or driving on hills or over obstacles, if you fail to take proper precautions. When I unloaded it from the truck I rolled it into the garage and initiated the shutdown procedures. Call 800-342-3764 for additional information.
I have a 2002 manual, but it looks like I have some differences in wiring. . All tie rod adjustments should be performed by an authorized Polaris dealer. At that point I loaded up the bike to take it back to the dealer. Mechanical energy is converted to electrical energy in the stator. The dealer ship Austin Power Sports of Independence Mo was awsome i would recomend them to anyone looking for a polaris.
Elevate the rear of the vehicle by placing a suitable stand under the frame. Do not use fuel with eth- anol content greater than 10 percent, such as E-85 fuel. E Emission Control System Service California Have an authorized Polaris dealer perform these services. So, for the third time I took the bike the 90 miles back down to Palmdale Supercycles. Never start the engine or let it run in an enclosed area. Paint Codes Replacement Keys Replacement keys can be made from the original key. Always use new cotter pins.
Alternator: Electrical generator producing voltage alternating current. Drive in a manner appropriate for your skills and operating conditions. In a sentence, I reversed the positive and negative on the battery like a dummy. Place a drain pan under the engine crankcase. Allow the oil to drain completely.
Maintenance intervals in the following charts are based upon average riding conditions and an average vehicle speed of approximately 10 miles per hour. Position the vehicle on a level surface. Allow the screen to air dry. A wagon, sled or other towed object does not have brakes or steering. Wash the oil pre-filter screen with solvent to remove any debris. If you get gasoline in your eyes or swallow gasoline, see your doctor immediately. Also, the shifter does not seem to do anything in the trans.
As she was in the house putting on her riding gear I attempted to get her bike warmed up. Remove the drain plug and pre-filter screen. Drive Chain Inspection - 90cc Models 1. While rotating the right front wheel, tighten the lower front brake adjuster nut on the right-hand control. Start the engine and allow it to warm up. I take it seriously and having the best is important to me. Chain Pitch: Distance between chain link pins No.
Monitor the oil level, and if it continues to rise, discontinue use and determine the cause or see your dealer. Inspect the filter support screen and clean away any oil or sediments in the air box. Allow the oil to drain completely. But they are not to fast on flat ground. Certain procedures require the use of special tools that are not available to the general public and your dealer will have to perform these procedures for you as necessary. Check the amount of chain slack by moving the vehicle slightly forward to gain chain deflection. Hot oil can cause burns to skin.
If the chain needs adjustment, use the procedure on page 135. Add the recommended oil as needed. Thrust your heel downward to crank the engine. Avoid crossing the side of any hill unless absolutely necessary. Never start the engine if you have a sticky throttle. Avoid steep hills 15 ° 2. Elevate the side of the vehicle by placing a suitable stand under the footrest frame.
Loosen drain screw and allow fuel in the float bowl and fuel line to drain completely. Never turn abruptly or at sharp angles. Antidote: External: Flush with water. Inspect the front shocks and springs to ensure proper function. I'm trying to rebuild it from the ground up. Inspect the swing arm and weldments for any sign of damage.