Try changing your fuel filter. I opened the hood and noticed there was diesel fuel sprayed under the engine compartment and also underneath the vehicle. Chrysler advised the consumer to continue to drive the vehicle until it malfunctions again. On every 98 318 injected truck, you must de-pressurixe the system before replacing any component in the system and use care for your eyes. Never saw one without one because of the cost of injector and engine damage under warranty. Still ran good tho, dispite the exact conditions you describe on Cold Start up.
They said there was contaminated fuel, water in fuel. Dodge and cummins should be ashamed. We here at Auto Parts Warehouse want to make sure you're happy with your car part purchases. Originally, we bought the wrong pump E7165M because we thought we had a 35 gallon tank. With the tank still on the ground, we hooked up the wires and started the truck to test it. Check engine light came on, but because it was dark driver was unaware of fuel leak until smoke was observed coming from engine.
Consumer states while driving the check engine light came on and the vehicle shut down and went into safe mode. Upon looking further, I noticed there was a broken fuel line that caused raw fuel to be sprayed in the engine compartment including directly onto the engine and underneath the vehicle onto the exhaust system. Don't waste your time wasting ours! I looked in my outside rear view mirrors and could see what appeared to be a mist spraying behind the vehicle. The cabin air filter is located on the passenger side of the cowl. Your Dodge Ram isn't worth much if you aren't able to drive it the way you want on and off the road. The truck is named for the Dodge ram hood ornament that the company has used on all of its cars since the 1930s. Then we wanted to know if the pump for the 35 gal tank would work on the 26 gal tank.
He agrees, atomized diesel touching a hot turbo could ignite, and we would have had a vehicle fire and become a flaming bomb with the entire family in the car. Start the engine, and check for leaks. The only way to change the filter is to drop the tank and remove the entire pump assembly. A bad fuel injector doesn't just affect your vehicle's fuel consumption, it affects others areas that make it harder and more expensive for you to get where you need to go. Your Dodge Ram may be designed to overcome any challenge that you encounter on the road, but a faulty fuel injector makes getting the most out of your vehicle a challenge. But, both Airtex pumps were a very tight fit, and we had to compress the pump to max to get the pump lid back attached properly back onto the tank, then it was bulging the bottom of the tank downward a little.
Smoke was rolling out of vehicle. It can be quite costly to replace since the entire unit must be replaced and the gas tank removed in order to do so. Maybe they ran out of them and changed it. To replace a fuel filter on a Dodge Ram with a gasoline engine, remove the fuel pump relay from the power distribution center. After opening the hood, remove the windshield wipers and the black covering 2 small T-30 screws, and a few body grommets. Most Dodge Ram owners are quite shocked to learn that the fuel filter is located inside the gas tank.
We're here to help with whateveve questions or concerns. Before this video, we dropped the tank to replace the fuel pump. Replace the old filter with the new one by pushing the new filter into the rubber grommet, and attach the filter with a new clamp. The fuel filter is in line on the pressure side of the fuel system. The fuel filter on a Dodge Ram is located inside the gas tank. Start the engine again, and run it until it stalls. Diesel fuel was spraying all over engine and was leaking down exhaust.
After you remove the cowl there will be a grey accordion looking filter in the cowl, remove that and replace with the new filter. Take the preventative road and order a performance enhanced fuel injector replacement for Dodge Ram from AutoZone and enjoy Same Day Story Pickup or ship to home. Discard the old fuel filter and the line clamp. So how do you find out what problems are occurring? Vehicle just out of warranty. I began to look for a safe place to pull off the road as I was pulling a trailer behind me. Eight injectors had to be replaced within the past year and some of the wires were replaced. Location depends on which engine you have.
Check these connections and look for any damage to the fuel lines. Additionally, the fuel filter on the left rear of the engine has a water bleed off knob on the bottom. They have ignored this, and it will take a death or serious injury before they get sued and fix things. Posted on Apr 30, 2010 This is the year that dodge decided to put the fuel filter in the gas tank instead of inline on the railing. Towed it home after a harrowing ordeal getting a wrecker there and trying to not get hit by cars.
When the consumer contacted Chrysler, he was informed repairs were not going to be authorized because the vehicle wa performing as designed. Let the people with 12+ years of experience in finding and buying car parts help you find the best Fuel Filter for your Dodge Ram 1500. It's next to the fuel pump. I noticed there was a recall on my truck for the defective water in fuel light. We should have used a board to distribute the weight evenly on the bottom of the tank. Ya, guess what… After completely installed, it did not work, not even the pump primer sound when we turned on the key and we validated power! Ok Joe Hello, every tank does have an initial screen to protect the pump internal parts, a screen, or sock as it is called.
We know you love your Dodge Ram 1500 and want to make sure it's taken care of maybe he or she even has a name? Nearly the same as all the other reports here. Remove the fuel line clamp along with the fuel filter. Pull and twist the fuel filter out of the rubber grommet. Loosen the clamps, slide off the hoses and slide them onto the new filter. It appears this is a common problem and is usually the 4 fuel line. I have heard so many bad things about this vehicle between the years of 2006 and 2007, I think it only fair the dealer should stand up for their product.