. Differential Gear Oil F250 Super Duty,F350 Super Duty Front,Dana 60 Axle 5. I went back with the Valvoline 75-140 synthetics and it has the modifier already in it. If so, the correct fluid is the 75w90 unless Ford just changed their mind again. Sep 22, 2010 first of all that fluid stinks!!! Lockup Differential Assembled with Axle Shafts and Backing Plates. For Single Wheel - Not For Dualie. Repeat this for the other cap.
Once the drive shaft has been removed, Remove the nut that holds the drive shaft yoke and slid the yoke off the differential shaft. For Single Wheel - Not For Dualie. For Single Wheel - Not For Dualie. When refilling, remove dipstick to provide adequate venting and allow oil to flow into crankcase. Lower the rear end off the jack stands with the floor jack. Im actually gonna be doin the same thing to my 99. Just got to get some longer bolts.
Not to be changed unless axle has been submerged in water. The Redline has been in there. Lockup Differential Assembled with Axle Shafts and Backing Plates. I bought a new 08 and up rear diff for the new superduty's cause they are aluminum and have fins. As in the standard Dana 80 axle that comes on all duallies? Good luck and hope this helps. Engine Oil F250 Super Duty,F350 Super Duty,6. Important: When refilling, remove dipstick to provide adequate venting and allow oil to flow into crankcase.
Be careful to keep the bearings in the caps. Differential Gear Oil F350 Super Duty Rear,Dana 80 8. Some applications may vary based on cooler size and if equipped with an in-tank cooler. Lockup Differential Assembled with Axle Shafts and Backing Plates. I bought royal purple oils.
Mar 06, 2014 These problems usually stems from a faulty speed sensor located on the rear differential unit. Lockup Differential Assembled with Axle Shafts and Backing Plates. The amount of transmission fluid and fluid level should be set by the indication on the dipstick's normal operating range. Approximate dry capacity including transmission fluid cooling system, actual refill capacities will vary based on vehicle application and transmission fluid cooling system. Add 8 oz of friction modifier Ford part no. Fuel Tank F250 Super Duty,F350 Super Duty,6. If not, remove the drive shaft.
Click on the following link for step by step instructions and pictures on removal and installation of the drive shaft. I would not be worried about the gears so much. Differential Gear Oil F250 Super Duty,F350 Super Duty Rear,Dana M80 8. Not very difficult to replace. Indicates only approximate dry-fill capacity. Not to be checked unless leak suspected. Differential Gear Oil F250 Super Duty,F350 Super Duty Front 5.
That will let you slid the differential from the axle housing once you unbolt the differential from the axle housing. According to the owners manual for all applications on a 2000 Ford Ranger. Especially if not noticed right away. Also check the front driveshaft rear end yoke seal. I just changed mine 2 weeks ago, it only had 35,000 on it and it was Royal Purple. I suspect that the dealer just got lazy. For Single Wheel - Not For Dualie.
The amount of transmission fluid and fluid level should be set by the indication on the dipstick's normal operating range. The owners manual also states to add 4 ounces 118 ml of friction modifier for a complete refill but I always thought the friction modifier was only added if you had a Traction - Lok axle - I would check with a Ford … dealer. Some vehicles have it on the transmission housing, but I believe yours is on the differential housing. You can always treat and paint your old cover. It was still real clean. Pull the floor jack out of the way. Don't forget to rate this post!! If there is no play remove the nut pull the yoke off replace the seal and reinstall in reverse order.
Helpfull depends on age and engine size but it no less than 5 and no more than 7 i'd suggest starting with 5 cause it wont hurt your engine if not the right amount and just check dipstick If it is a diesel it is more like 4 gallons. Add 118 ml 4 ounces of friction mod … ifier for complete refill of Traction - Lok axle. Add 8 oz of friction modifier Ford part no. Also now would be the time to change out your rear diff cover if its gettin rusty. All of the components you mentioned get their signals from the speed sensor.
The manual also states the fluid is good for the life of the vehicle and is not to be checked or changed unless a leak is suspected , service work is being done , or the axle has been submerged in water According to the owners manual , the rear differential takes 2. The following is out of the August 2006 version of the Ford workshop manual. I'm thinking about changing it out. Tap the socket extension with the dead blow hammer until the universal joint cap comes out of the yoke. Standard Metric Fluid Spec Note Air Cond Refrigerant F250 Super Duty,F350 Super Duty 1. Dana rear axles also contain a synthetic lubricant but do required a change.